Product ID:5957C, CROSS-LINKER, (SEE SUPPL.)
MSDS Date:01/01/1999
FSC:1560
NIIN:01-252-4991
Status Code:A
Kit Part:Y
MSDS Number: CLGJC

ENGINEERED FABRICS CORPORATION

669 GOODYEAR STREET
ROCKMART, GA 30153
US

Emergency Phone: (800)424-9300

Info Phone: 706-684-7855

Preparer: WILLIAM R. RITTER

Cage: 56221

ENGINEERED FABRICS CORPORATION

548 ROCKMART, GA 30153 US

Telephone: 706-684-7855

Cage: 56221

DIETHYLTOLUENEDIAMINE

CAS: 68479-98-1

2-BUTANONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Health Hazards Acute and Chronic:ACUTE: CONTACT WITH THE EYE CAN CAUSE
SEVERE IRRITATION, REDNESS, TEARING AND BLURRED VISION. PROLONGED
EXPOSURE MAY CAUSE SKIN IRRITATION. CHRONIC: IN RARE INSTANCES,
SENSITIZATION TO DIETHYLTOLUENED IAMINE HAS BEEN REPORTED TO OCCUR
IN HUMANS. A TWO YEAR FEEDING STUDY IN RATS SHOWED DETDA CAUSED
EFFECTS IN THE PANGREAS, LIVER, THYROID, AND EYES. AN INCREASE IN
THE NUMBER OF TUMERS IN THE LIVER AN D THYROID OF MALE RATS AND IN
THE LIVER AND POSSIBLY MAMMARY GLANDS OF FEMALE RATS WAS FOUND.
Effects of Overexposure:EYE CONTACT: SEVERE IRRITATION, REDNESS,
TEARING AND BLURRED VISION. SKIN CONTACT: IRRITATION. IN RARE
INSTANCES, SENSITIZATION TO DIETHYLTOLUENEDIAMINE HAS BEEN REPORTED
TO OCCUR IN HUMANS
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN, OR
RESPIRATORY DISORDERS MAY BE AGGRAVATED DUE TO EXPOSURE TO THIS
PRODUCT.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING DIFFICULT,
ADMINISTER OXYGEN. IF BREATHING STOPPED, GIVE ARTIFICIAL
RESPIRATION. KEEP WARM, QUIET, GET MEDICAL ATTENTION. EYES: FLUSH
WITH LARGE AMOUNTS O F WATER, LIFTING UPPER AND LOWER LIDS
OCCASIONALLY. GET MEDICAL ATTENTION. SKIN: WASH EXPOSED AREA WITH
SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. LAUNDER BEFORE
REUSE. INGESTION: GIVE TWO GLASSES OF WATER AND INDUCE VOMITING BY
STICKING FINGER DOWN THROAT. CALL PHYSICIAN. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.

Flash Point Method:CC
Flash Point:=-8.7C, 16.F
Lower Limits:1.4@200F,MEK
Upper Limits:11.4, MEK
Extinguishing Media:ALCOHOL FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:TOXIC GASES AND VAPORS MAY BE RELEASED BY
THERMAL DECOMPOSITION. FIREFIGHTERS SHOULD USE A SELF-CONTAINED
BREATHING APPARATUS WITH A FULL FACEPIECE UNDER POSITIVE PRESSURE.
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR MAY BE MOVED BY VENTILATION AND BE
IGNITED AT LOCATIONS DISTANT FROM THE MATERIAL HANDLING POINT.

Spill Release Procedures:REMOVE IGNITION SOURCES. VENTILATE AREA. WEAR
PERSONAL PROTECTIVE EQUIPMENT. DIKE OR CONTAIN SPILL WITH ADSORBANT
OR OTHER MATERIAL. DO NOT ALLOW SPILL TO DISCHARGE INTO STORM OR
SANITARY SEWER. PUMP OR BAIL MATERIAL BACK INTO ORIGINAL CONTAINER
OR CLEAN, EMPTY CONTAINER OF SAME SPECIFICATION. ALL CLEANING
MATERIALS AND WASTE PRODUCT ARE HAZARDOUS WASTE. EPA RCRA ID NO.
D001, F005 (40 CFR 261).

Handling and Storage Precautions:THE STORAGE AREA SHOULD BE WELL
VENTILATED. STORE AWAY FROM SOURCES OF HEAT AND OPEN FLAMES. KEEP
CONTAINER CLOSED WHEN NOT IN USE.

Respiratory Protection:IF WORKPLACE CONCENTRATIONS EXCEED THE
RECOMMENDED TLV'S, USE A NIOSH/MSHA-APPROVED RESPIRATOR TO PREVENT
OVEREXPOSURE. IN ACCORDANCE WITH 29 CFR 1910.134 USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPORS.
Ventilation:PROVIDE ADEQUATE EXPLOSION-PROOF VENTILATION TO MAINTAIN
VAPORS BELOW THE TLV'S.
Protective Gloves:BUTYL
Eye Protection:CHEMICAL GOGGLES. CONTACT LENSES SHOULD NOT BE WORN.
Other Protective Equipment:WEAR IMPERVIOUS PROTECTIVE CLOTHING TO
PREVENT SKIN CONTACT.
Supplemental Safety and Health
THIS ENTRY DESCRIBES SECOND PART, SERIAL NUMBER "CLGJC, 5957C,
CROSS-LINKER", OF A TWO PART KIT, TRADE NAME 82C32 KIT,
POLYURETHANE CEMENT. SEE THIS SAME NSN, SERIAL NUMBER "CLGJB, PART
82C31, POLYURE THANE CEMENT BASE" FOR DATA ON SECOND PART OF KIT.

HCC:F2
Boiling Pt:B.P. Text:NA
Melt/Freeze Pt:M.P/F.P Text:NA
Vapor Pres:NE
Vapor Density:NE
Spec Gravity:0.90
pH:NA
VOC Grams/Liter:3.76
Solubility in Water:SOLUBLE IN WATER.
Appearance and Odor:CLEAR LIQUID, AMINE ODOR.
Percent Volatiles by Volume:56

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAMES.
Hazardous Decomposition Products:CO, CO2, NOX.

Waste Disposal Methods:COMPLY WITH ALL FEDERAL, STATE, LOCAL LAWS, AND
REGULATIONS APPLICABLE TO PACKAGING, MANIFESTING, TRANSPORTING, AND
DISPOSING OF HAZARDOUS WASTE. EPA RCRA ID NUMBER: D001, F005
REFERENCE 40 CFR 261.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:EPA RCRA ID NUMBER: D001,F005 REFERENCE 40 CFR 261.

Transport Information:DOT SHIPPING NAME: FLAMMABLE LIQUID, N.O.S.,
(METHYL ETHYL KETONE). TECHNICAL SHIPPING NAME: 5957C. DOT HAZARD
CLASSIFICATION: FLAMMABLE LIQUID. FREIGHT CLASSIFICATION:
CHEMICALS, N.0.I. , NMFC-100, I TEM # 43940 SUB. 2. UN 1993;
HAZARDOUS CLASS: 3, PG I I; DOT LABELS REQUIRED: FLAMMABLE LIQUID.
ERG #: 128. EPA/DOT HAZARDOUS SUBSTANCES RQ: YES (METHYL ETHYL
KETONE 5000 LBS.)

SARA Title III Information:SARA SECTION 313: METHYL ETHYL KETONE
(2-BUTANONE), REPORTABLE; RQ = 5000 LBS.
State Regulatory Information: